Product ID:N-5114 GRAY SILICONE ENAMEL
MSDS Date:06/29/2000
FSC:8010
NIIN:01-344-5310
Status Code:A
MSDS Number: CKZCD

NILES CHEMICAL PAINT

225 FORT STREET
NILES, MI 49120
US

Emergency Phone: 219-236-5856

Info Phone: 616-683-3377/219-236-5856

Preparer: ERNEST CARTER

Cage: 02388

NILES CHEMICAL PAINT

307 NILES, MI 49120 US

Telephone: 616-683-3377/219-236-5856

Cage: 02388

NATURAL CALCIUM CARBONATE

CAS: 1317-65-3

RTECS: EV9580000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

HIGH SOLIDS SILICONE

MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

OSHA PEL 2900 MG/M3;500 PPM

ACGIH TLV: 525 MG/M3;100 PPM

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

LIGHT AROMATIC SOLVENT NAPHTHA (PETROLEUM)

CAS: 64742-95-6

RTECS: WF3400000

ZINC OXIDE (ZNO)

CAS: 1314-13-2

RTECS: ZH4810000

OSHA PEL 15 MG/M3

AMORPHOUS SYNTHETIC SILICA GEL

CAS: 112926-00-8

RTECS: VV7315000

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 10 MG/M3

COBALT

CAS: 7440-48-4

RTECS: GF8750000

OSHA PEL 0.1 MG/M3

ACGIH TLV: 0.02 MG/M3

Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION LACRIMATION,
REDNESS, BLURRED VISION, VISUAL DISTURBANCE AND EYE BURNS.
SKIN:HARMFUL IF ABSORBED THROUGH SKIN. CAN BE ABSORBED IN TOXIC
AMOUNTS.
Explanation of Carcinogenicity:COBALT IS LISTED AS A GROUP 2B
CARCINOGEN.
Effects of Overexposure:BREATHING: NASAL AND RESPIRATORY IRRITATION,
CNS DEPRESSION (DIZZINESS, DROWSINESS, WEAKNESS, FATIGUE.
CONFUSION, NASEA, HEADACHE, VERTIGO, POSSIBLE UNCONSCIOUSNESS, EVEN
ASPHYXIATION. LIVER, KIDNEYS CNS, CNS EFFECTS AND KIDNEY AND LIVER
DAMAGE,
Medical Cond Aggravated by Exposure:NONE KNOWN.

First Aid:INHALATION: MOVE VICTIM TO FRESH AIR AT ONCE. IF BREATHING
HAS STOPPED. PERFORM ARTIFICIAL RESPIRATION GET MEDICAL ATTENTION
AS SOON AS POSSIBLE. SKIN: WASH WITH SOAP AND WATER. EYE CONTACT:
IMMEDIATE LY FLUSH EYES WITH LARGE AMOUNT OF WATER FOR AT LEAST 15
MINUTES. SWALLOWING: INDUCE VOMITING IMMEDIATELY BY GIVING 2
GLASSES OF WATER AND STICKING FINGER DOWN THROAT.

Flash Point Method:TCC
Flash Point:=41.7C, 107.F
Lower Limits:0.7
Upper Limits:36.0
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN POSITIVE PRESSURE MODE AND FULL
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:KEEP CONTAINER TIGHTLY CLOSED. ISOLATE
FROM HEAT, SPARKS, ELECTRICAL EQUIPMENT, AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. APPLICATION
TO HOT SURFACES REQUIRES SPECI AL PRECAUTIONS. DURING EMERGENCY
CONDITIONS, OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A
HEALTH HAZARD.

Spill Release Procedures:ABSORB WITH AN INERT MATERIAL SUCH AS CLAY,
SOIL, OR A COMMERCIALLY AVAILABLE ABSORBENT.DIKE TO PREVENT FURTHER
MOVEMENT AND RECLAIM INTO RECOVERY OR SALVAGE DRUMS OR TANK TRUCK
FOR DISPOSAL.

Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR FIRE OR OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT
IN USE .
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD OR FLAME CUT ON EMPTY DRUM.

Respiratory Protection:WEAR AN APPROPRIATE (TYPE TC -23C-75) PROPERLY
FITTED HALF-MASK OR FULL FACEPIECE RESPIRATOR.
Ventilation:SUFFICIENT VENTILATION IN VOLUME AND PATTERN SHOULD BE
PROVIDED TO KEEP THE AIR CONCENTRATION BELOW CURRENT APPLICABLE
OSHA SURFACES.
Protective Gloves:WEAR CHEMICAL RESISTANT (NITRILE OR VITON) GLOVES
Eye Protection:WEAR CHEMICAL GOGGLES.SAFETY GLASSES, OR FACE SHIELDS.
Work Hygienic Practices:EMPLOYEES SHOULD WASH PROMPTLY WHEN SKIN
CONTACT. IF POTENTIAL FOR EYE CONTACT REMOVE ANY CLOTHING THAT
BECOMES WET.
Supplemental Safety and Health

Boiling Pt:<203.3C, 398.F
B.P. Text:146-398 DEG F
Vapor Density:> AIR
Spec Gravity:1.440
VOC Grams/Liter:2.76
Viscosity:99 % V MAX
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:YES
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Percent Volatiles by Volume:41.10
Corrosion Rate:NINIMAL

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ACIDS AND BASES AND OXIDIZERS, OXIDIZING
AGENTS, NONE KNOWN, STRONG ACIDS, ALKALIES
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND/OR
CARBON DIOXIED.
Conditions to Avoid Polymerization:WILL NOT OCCUR

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOACL,
STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.